Search found 71 matches

by Uli-RT
Sun Mar 06, 2022 2:23 pm
Forum: Volvo TGB/30X Modifications and restorations
Topic: Where does my brake fluid go?
Replies: 10
Views: 2512
Germany

Re: Where does my brake fluid go?

Hello Marcus,
did you reset the warning valve? If not, this could be the cause of the problem or the defect in the other brake servo. Just open it up and see if there's brake fluid in it, then you'll know.
Regards
Uli

https://www.c303.de/c303-pdf/service/se ... rakes3.pdf
by Uli-RT
Sat Dec 25, 2021 3:11 pm
Forum: Volvo TGB/30X Modifications and restorations
Topic: Where does my brake fluid go?
Replies: 10
Views: 2512
Germany

Re: Where does my brake fluid go?

...and make sure that you also change the small o-ring (number 3 in the picture).
by Uli-RT
Sat Dec 25, 2021 3:03 pm
Forum: Volvo TGB/30X Modifications and restorations
Topic: Where does my brake fluid go?
Replies: 10
Views: 2512
Germany

Re: Where does my brake fluid go?

You have to pull off the main membrane, then a metal pin approx. 15mm wide will appear in the groove. Lay the brake booster on its side, the cotter pin points downwards, press the siphon lid in very lightly ... lift the whole thing up once and let it fall onto the table with a jerk, then the cotter ...
by Uli-RT
Tue Oct 05, 2021 1:30 pm
Forum: Volvo TGB/30X Modifications and restorations
Topic: FRONT BRAKES, WHEEL CYLINDERS AND OTHER STUFF
Replies: 2
Views: 1351
Germany

Re: FRONT BRAKES, WHEEL CYLINDERS AND OTHER STUFF

If you haven't had any success yet, here is another tip. One of the highest points in the braking system is with the brake boosters. There is no vent screw here. You can only open the banjo screw and try to get some air out of the system. Otherwise, the only thing that helps is a lot of patience and...
by Uli-RT
Fri Mar 19, 2021 4:46 pm
Forum: Volvo TGB/30X series Engine and Driveline
Topic: Newbie with some Questions
Replies: 7
Views: 4032
Germany

Re: Newbie with some Questions

To deactivate the automatic all-wheel drive, the 4 cables on the transfer case must be loosened. The black / white cables must be connected. Isolate the other two black cables, they are not connected anywhere. then you can continue to use the all-wheel switch in the dashboard and the automatic conne...
by Uli-RT
Wed May 13, 2020 12:10 pm
Forum: Volvo TGB/30X series Engine and Driveline
Topic: Air intake before filter
Replies: 2
Views: 3358
Germany

Re: Air intake before filter

The part is only used with the 3-part intake manifold. I did not include it when converting from 1-part to 3-part. Works fine.
by Uli-RT
Wed May 13, 2020 12:01 pm
Forum: Volvo TGB/30X body and electrical
Topic: 4WD electronics
Replies: 15
Views: 15012
Germany

Re: 4WD electronics

Are you shure that the new Valve is working the right way?
It should open if you put power on it.
If it is closed, you have vakuum and 4WD is OFF.
by Uli-RT
Tue May 12, 2020 3:12 pm
Forum: Volvo TGB/30X body and electrical
Topic: 4WD electronics
Replies: 15
Views: 15012
Germany

Re: 4WD electronics

If 4WD ist NOT engaged, the Valve is working.
Without electricity the Valve opens, and 4WD is engaged.
If you can hear the Valve, may be there is some dirt in the air intake of the valve.
If you take of the hose of the Valve 4WD should be engaged.
by Uli-RT
Thu May 07, 2020 3:16 pm
Forum: Volvo TGB/30X body and electrical
Topic: How to reconnect a hose to a windshield washer nozzle
Replies: 2
Views: 3325
Germany

Re: How to reconnect a hose to a windshield washer nozzle

Hi Marcus,

you have to take the nozzle out. There is no other way to connect the hose to the nozzle.

Regards
Uli
by Uli-RT
Tue Dec 24, 2019 3:37 am
Forum: Volvo TGB/30X series Engine and Driveline
Topic: Flange Leak
Replies: 3
Views: 4709
Germany

Re: Flange Leak

Hello Jim, I bought a complete set for € 40. The shaft seal has the original size. The repair sleeve is very thin. Installation tool is included. Takes a few minutes. Very easy to assemble. Under no circumstances make it hot. The parts are available from Claas (Friese in the C303.de Forum) in German...
by Uli-RT
Sat Dec 21, 2019 11:02 am
Forum: Volvo TGB/30X series Engine and Driveline
Topic: Flange Leak
Replies: 3
Views: 4709
Germany

Flange Leak

Hello everybody,
should anyone have problems with flange leaks,
there is a solution at SKF.
greetings
Uli

Image

Image

Image
by Uli-RT
Thu Oct 11, 2018 1:36 pm
Forum: Volvo TGB/30X series Engine and Driveline
Topic: Volvo C303 - uneven braking
Replies: 12
Views: 11468
Germany

Re: Volvo C303 - uneven braking

If you need any repairkits you can call "Friese"=Claas in Germany on the German C303-Forum:
https://www.c303.de/c303-forum/index.ph ... #msg113203
by Uli-RT
Thu Oct 04, 2018 1:33 pm
Forum: Volvo TGB/30X series Engine and Driveline
Topic: Volvo C303 - uneven braking
Replies: 12
Views: 11468
Germany

Re: Volvo C303 - uneven braking

If the pressure in all tires is the same I first would give the right side one more klick to the brake shoes.
You have to try that out. May be there is only one brakeshoe possible to move nearer to the drum.
by Uli-RT
Fri Apr 20, 2018 5:21 am
Forum: Volvo TGB/30X series Engine and Driveline
Topic: CV Boot Question
Replies: 25
Views: 22674
Germany

Re: CV Boot Question

FMV is closed. No further action, as far as I know.

You can contact Claas in Germany 4scirocco(add)web.de
He has many new rebuild parts. There is no website.

Regards
Uli